The Case for Hydrogen in Transport

In the last post I looked at the problem of generating electricity, and found that one of the problems is demand smoothing One approach to this is to look at the transport problem, the other major energy demand system. Currently we fill our tanks with petroleum derived products, and everything is set for that. However, battery-powered cars would remove the need for petrol, and if they were charged overnight, they would help this smoothing problem. The biggest single problem is that this cannot be done because there is not enough of some of the necessary elements to make it work. Poorer quality batteries could be made, but there is another possibility: the fuel cell.

The idea is simple. When electricity is not in high demand, the surplus is used to electrolyse water to hydrogen and oxygen. The hydrogen is stored, and when introduced to a fuel cell it burns to make water while generating electricity. Superficially, this is ideal, but there are problems. One is similar to the battery – the electrodes tend to be made of platinum, and platinum is neither cheap nor common. However, new electrodes may solve this problem. Platinum has the advantage that it is very unreactive, but the periodic servicing of the cell and the replacing of electrodes is realistic, and of course recycling can be carried out because unlike the battery, it would be possible to merely recycle the electrodes. (We could also use pressurised hydrogen in an internal combustion engine, with serious redesign, but the efficiency is simply too low.)

One major problem is storing the hydrogen. If we store it as a gas, very high pressures are needed to get a realistic mass to volume ratio, and hydrogen embrittles metals, so the tanks, etc., may need servicing as well. We could store it as a liquid, but the boiling point is -259 oC. Carting this stuff around would be a challenge, and to make matters worse, hydrogen occurs in two forms, ortho and para, which arise because the nuclear spins can be either aligned or not. Because the molecule is so small there is an energy difference between these, and the equilibrium ratio is different at liquid temperatures to room temperatures. The mix will slowly re-equilibrate at the low temperature, give off heat, boil off some hydrogen, and increase the pressure. This is less of a problem if you have a major user, because surplus pressure is relieved when hydrogen is drawn off for use, and if there is a good flow-through, no problem. It may be a problem if hydrogen is being shipped around.

The obvious alternative is not to ship it around, but ship the electricity instead. In such a scenario for smaller users, such as cars, the hydrogen is generated at the service station, stored under pressure, and more is generated to maintain the pressure. That would require a rather large tank, but it is doable. Toyota apparently think the problem can be overcome because they are now marketing the Mirai, a car powered by hydrogen fuel cells. Again, the take-up may be limited to fleet operators, who send the vehicles out of central sites. Apparently, the range is 500 km and it uses 4.6 kg of hydrogen. Hydrogen is the smallest atom so low weight is easy, except the vehicle will have a lot of weight and volume tied up with the gas pressurized storage. The question then is, how many fuel stations will have this very large hydrogen storage? If you are running a vehicle fleet or buses around the city, then your staff can refill as well, which gets them to and from work, but the vehicle will not be much use for holidays unless there are a lot of such stations.

Another possible use is in aircraft, but I don’t see that, except maybe small short-haul flights driven by electric motors with propellors. Hydrogen would burn well enough, but the secret of hydrocarbons for aircraft is they have a good energy density and they store the liquids in the wings. The tanks required to hold hydrogen would add so much weight to the wings they might fall off. If the main hull is used, where do the passengers and freight go? Another possibility is to power ships. Now you would have to use liquid hydrogen, which would require extremely powerful refrigeration. That is unlikely to be economic compared with nuclear propulsion that we have now.

The real problem is not so much how do you power a ship, or anything else for that matter, but rather what do you do with the current fleet? There are approximately 1.4 billion motor vehicles in the world and they run on oil. Let us say that in a hundred years everyone will use fuel cell-driven cars, say. What do we do in the meantime? Here, the cheapest new electric car costs about three times the cost of the cheapest petrol driven car. Trade vans and larger vehicles can come down to about 1.5 times the price, in part due to tax differences. But you may have noticed that government debt has become somewhat large of late, due to the printing of large amounts of money that governments have promptly spent. That sort of encouragement will probably be limited in the future, particularly as a consequence of shortages arising from sanctions. In terms of cost, I rather think that many people will be hanging on to their petrol-powered vehicles, even if the price of fuel increases, because the difference in the price of fuel is still a few tens of dollars a week tops, whereas discarding the vehicle and buying a new electric one involves tens of thousands of dollars, and with the current general price increases, most people will not have those spare dollars to throw away. Accordingly, in my opinion we should focus some attention on finding an alternative to fossil fuels to power our heritage fleet.

1 thought on “The Case for Hydrogen in Transport

  1. Ship the ammonia around the world to depots for buses and trucks fueled by hydrogen cells. These will dissociate the ammonia to recover the hydrogen. Berkeley-Albany in California has been operating a large fleet of fuel cells hydrogen buses which the TRUMP administration found exceeded maximum expectations in ALL parameters.

Leave a Reply

Fill in your details below or click an icon to log in: Logo

You are commenting using your account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s